Toyota HiAce (H200) (2004-2013) Fuse Diagram

Advertisements

Fuse box diagram (fuse layout), location, and assignment of fuses and relays Toyota HiAce (H200) (2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013).

Checking and Replacing Fuses

The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.

  • Turn the engine switch off (with a smart key system – turn the “ENGINE START STOP” switch off) and turn off all electrical accessories.
  • Open the fuse box cover.
  • See diagrams below for details about which fuse to check.
  • Remove the fuse.
  • Check if the fuse is blown – if the thin wire inside is broken, the fuse has blown.
  • Replace the blown fuse with a new fuse of an appropriate amperage rating.

Notice

  • Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse, even as a temporary fix. This can cause extensive damage or even fire.
  • Always use a genuine Toyota fuse or equivalent.
  • Do not modify the fuses or fuse boxes.
  • If the replaced fuse blows again, have the vehicle inspected by any authorized Toyota dealer or repairer, or another duly qualified and equipped professional.

Passenger Compartment

Left-hand drive

Passenger Compartment (LHD)

Right-hand drive

Passenger Compartment (RHD)

  1. Fuse Box
  2. Integration Relay
  3. Junction Block
  4. Transponder Key Amplifier
  5. Shift Lock Control ECU
  6. A/C Amplifier
  7. Clearance Warning ECU
  8. Additional Fuse Box
  9. Transmission Control ECU
  10. Relay Box
  11. Airbag Sensor Assembly Center
  12. Turbo Motor Driver
  13. Junction Connector (CAN)

 

Passenger Compartment Fuse Box Diagram

The fuse panel is located under the left side of the dashboard. Remove the cover.

Left-hand drive

Passenger Compartment Fuse Box Location (LHD)

Right-hand drive

Passenger Compartment Fuse Box Location (RHD)

Advertisements

 

Passenger Compartment Fuse Box Diagram

№FuseACircuit
1-- -
2ACCL INT LCK25 -
3WIP25Windshield wipers
4RR WIP-WSH15Rear window wipers and washer
5WSH20Window wipers and washer, rear window wipers and washer
6ECU-IG7.5Air conditioning system, automatic transmission shift lock control system, anti-lock brake system, sliding door closer system, multiport fuel injection system/sequential multiport fuel injection system, multiplex communication system
7GAUGE10Gauges and meters, rear turn signal lights, stop/tail lights, back-up lights, rear window defogger, electric cooling fans, charging system, air conditioning system, power windows
8OBD7.5On-board diagnosis system
9STOP10Rear turn signal lights, stop/tail lights, back-up lights, high-mounted stoplight
10-- -
11DOOR30Power windows, power door lock system
12RR HTR15Air conditioning system
13-- -
14FR FOG15Before Apr. 2012: Front fog light
10From Apr. 2012: Front fog light
15AM130All components in "ACC”, and "CIG” fuses, starting system
16TAIL10Front position lights, rear turn signal lights, stop/tail lights, back-up lights, license plate lights, clock, instrument panel light, multiport fuel injection system/sequential multiport fuel injection system
17PANEL10Instrument panel light
18A/C10Air conditioning system
19-- -
20-- -
21-- -
22-- -
23CIG15Cigarette lighter
24ACC7.5Power rear view mirror, automatic transmission shift lock control system
25--
26ELS10Multiport fuel injection system/sequential multiport fuel injection system
27AC100V15 -
28RR FOG15Rear turn signal lights, stop/tail lights, back-up lights
29-- -
30IGN15Multiport fuel injection system/sequential multiport fuel injection system, electronic throttle control system, SRS airbag system
31MET IGN10Gauges and meters

Passenger Compartment Fuse Box Diagram

№FuseACircuit
1POWER30Power windows
2DEF30Rear window defogger
3-- -
Relay
R1Ignition (IG1)
R2Heater (HTR)
R3Flasher

Advertisements

 

Relay Box

It is below the glove box. Push the tab and remove the cover.

Relay Box Diagram

№FuseACircuit
1HEAD LL15 -
2HEAD RL15 -
3HEAD LH15Left-hand headlight
4HEAD RH15Right-hand headlight
5ST7.5Starting system, multiport fuel injection system/sequential multiport fuel injection system, gauges and meters
6A/C №37.5Air conditioning system
7-- -
Relay
R1 -
R2Headlight (HEAD)
R3 -
R4Starter (ST)
R5(OSV)
R6 -
R7Front fog light (FR FOG)
R8Air conditioner compressor clutch (MG CLT)
R9(INJ/IGN)

Passenger Compartment

  1. Door Control Relay (RH)
  2. Door Control Relay (Power Slide Door)
  3. Door Control Receiver
  4. Door Control Relay (LH)
  5. Door Opening Relay

Engine Compartment

Engine Compartment

  1. 1KD-FTV, 2KD-FTV, 5L-E: Fuse Box
  2. 1TR-FE, 2TR-FE: Fuse Box
  3. Additional Fuse Box
  4. Before Aug. 2010:Cooling Fan ECU №2
  5. Skid Control ECU with Actuator
  6. From Aug. 2010:Cooling Fan ECU №2
  7. Injector Driver (EDU)
  8. From Aug. 2010:Cooling Fan ECU №1
  9. Before Aug. 2010:Cooling Fan ECU №1
  10. Engine ECU
  11. 1TR-FE, 2TR-FE: Air Injection Control Driver
    1KD-FTV, 2KD-FTV: Injection Driver (EDU)

Advertisements

 

Engine Compartment Fuse Box Diagram

Push the tab and remove the cover.

Engine Compartment Fuse Box Diagram

№FuseACircuit
1A/F151TR-FE, 2TR-FE: Multiport fuel injection system/sequential multiport fuel injection system
EDU251KD-FTV, 2KD-FTV, 5L-E: Multiport fuel injection system/sequential multiport fuel injection system
2HAZ-HORN15Horns, emergency flasher
3EFI201TR-FE, 2TR-FE: Electronically controlled fuel pump, multiport fuel injection system/sequential multiport fuel injection system, electronic throttle control system
251KD-FTV, 2KD-FTV, 5L-E: Electronically controlled fuel pump, multiport fuel injection system/sequential multiport fuel injection system, electronic throttle control system
4-- -
5ALT140All components in "MAIN3”, "FAN1”, "FAN2” and "GLOW” fuses
150Refrigerator Van: All components in "MAIN3”, "FAN1”, "FAN2” and "GLOW” fuses
6A/PUMP501TR-FE, 2TR-FE: Emission control system
GLOW801KD-FTV, 2KD-FTV, 5L-E: Engine glow system
7MAIN350All components in "A/F”, "HAZ-HORN” and "EFI” fuses
8FAN250Electric cooling fans
9FAN3301KD-FTV, 2KD-FTV, 5L-E: Electric cooling fans
10FAN150Electric cooling fans
11PTC1501KD-FTV, 2KD-FTV: PTC Heater
12MAIN4120All components in "WELCAB”, "AC100V”, "RR FOG”, "RR HTR”, "OBD”, "STOP”, "AM1”, "DOOR”, "FR FOG”, "PWR”, "DEF”, "ELS”, "TAIL”, "PANEL”, "ECU-IG”, "WIP”, "WSH”, "GAUGE”, "RR WIP-WSH” and "A/C” fuses
13-- -
14HTR40Air conditioning system
15-- -
16RR CLR30Rear air conditioner
17PTC2501KD-FTV, 2KD-FTV: PTC Heater
Relay
R11TR-FE, 2TR-FE: Rear air conditioner (RR CLR)
R21KD-FTV, 2KD-FTV, 5L-E: Engine glow system (GLOW)
R31KD-FTV, 2KD-FTV, 5L-E: Rear air conditioner (RR CLR)
R41KD-FTV, 2KD-FTV: PTC Heater (PTC2)
R5Electric cooling fans (FAN1)
R61KD-FTV, 2KD-FTV: PTC Heater (PTC1)
R7Electric cooling fans (FAN2)

Additional Fuse Box

Additional Fuse Box

№FuseACircuit
1ECU-B10Multiplex communication system, sliding door closer system, air conditioning system, wireless remote control system
2ETCS101TR-FE (from Apr. 2012), 2TR-FE: Electronic throttle control system
A/F151KD-FTV with DPF: A/F heater, Electronically controlled fuel pump
3PSD25Sliding door closer system
4ABS SOL25Anti-lock brake system
5TVSS15
6DOME10Personal lights, interior lights, step lights, gauges and meters
7RADIO15Audio system
8ALT-S7.5Charging
9D.C.C30All components in "RADIO” and "DOME” fuses
10HEAD40Headlight
11ABS MTR40Anti-lock brake system
12--Before Apr. 2012: -
13RR DOOR30Sliding door closer system
14AM230All components in "IGN” and "MET IGN” fuses, starting system, multiport fuel injection system/sequential multiport fuel injection system
15--From Apr. 2012: -
16--From Apr. 2012:  -
17--From Apr. 2012:  -
18--From Apr. 2012: -
19--From Apr. 2012:  -

 

Advertisements

Advertisements